Utilization of Chili Citrus (Citrus microcarpa) as a Natural Fixator for Dyeing Cotton Fabrics with Dayak Onion Tuber Extract (Eluetherine palmifolia (L.) Merr)

Authors

  • Ida Ayu Made Tania Widyasari Universitas Tanjungpura, Indonesia
  • Masriani Masriani Universitas Tanjungpura
  • Hairida Hairida Universitas Tanjungpura

DOI:

https://doi.org/10.33394/hjkk.v12i5.12917

Keywords:

natural dyes, fixator, Dayak onion bulbs, orange chili sauce

Abstract

The high demand for the textile industry can pollute the environment through waste. Natural dyes from natural ingredients are used as a step to minimize this waste.  Dayak onions can be used as a natural dye because they produce a red color from anthocyanin compounds. However, natural dyes have weaknesses, namely that the color is less stable and fades easily, so a fixator is needed. Fixator is used to strengthen the color in fabrics that use natural dyes. Orange chili sauce has the potential to be a natural fixator because it contains citric acid. This research aims to analyze the effect of the concentration of chili pepper fixator (Citrus microcarpa) on the color fastness of cotton fabric using natural dyes from Dayak onion bulbs (Eleutherine palmifolia (L.) Merr). The research method used was an experiment using a colorimeter application whose results were in the form of ΔE values. The test was carried out on the color of the fabric that had been dyed and fixed and then the average value (ΔE) was measured before and after washing the soap. The research results showed that the average value (ΔE) of the smallest to largest fixator was a concentration of 20%, 100%, 0%, 40%, 60% and 80%. Based on the results of the Kruskal Wallis test followed by the Bonferroni test, a significant value of 0.024 (p>0.05) was obtained at a concentration of 20%. This shows that the chili lime fixator has a significant influence on the fastness of the fabric.

Author Biographies

Ida Ayu Made Tania Widyasari, Universitas Tanjungpura

Pendidikan Kimia FKIP UNTAN

Masriani Masriani, Universitas Tanjungpura

Pendidikan Kimia FKIP UNTAN

Hairida Hairida, Universitas Tanjungpura

Pendidikan Kimia FKIP UNTAN

References

Adelina, K., Wardenaar, E., & Sisillia, L. (2014). Kajian Etnobotani dan Fisiko Kimia Kulit Kayu Laban ( Vitex pubescens Vahl) di Desa Lape Kecamatan Kapuas Kabupaten Sangau Kalimantan Barat. Jurnal Hutan Lestari, 2(1), 92–99.

Adriani, & Atmajayanti, C. (2023). Pengaruh Mordan Tunjung Dan Kapur Sirih Terhadap Hasil Ecoprint Daun Iler (Coleus scutellarioides Linn. Benth). Gorga: Jurnal Seni Rupa, 12(1), 230–236.

Al-Tohamy, R., Ali, S. S., Li, F., Okasha, K. M., Mahmoud, Y. A.-G., Elsamahy, T., Jiao, H., Fu a, Y., & Sun, J. (2022). A critical review on the treatment of dye-containing wastewater: Ecotoxicological and health concerns of textile dyes and possible remediation approaches for environmental safety. Journal Ecotoxicology and Environmental Safety, 231.

Ali, S. S., Al-Tohamy, R., & Sun, J. (2002). Performance of Meyerozyma caribbica as a novel manganese peroxidase-producing yeast inhabiting wood-feeding termite gut symbionts for azo dye decolorization and detoxification. Journal Science of The Total Environment, 806.

Andansari, D., & Nadir, M. (2017). Eksplorasi Pewarnaan Beberapa Jenis Kain Menggunakan Pewarna Alami Jowale Dan Secang Dengan FIksasi Tawas, Baking Soda Dan Jeruk Nipis. Jurnal Kreatif Desain Produk Industri Dan Arsitektur, 4(2), 32–40.

Anggraeni, A., Pringgenies, D., & Ridlo, A. (2023). Pewarna Alami Limbah Mangrove Dengan Fiksasi Air Kelapa, Asam Jawa Dan Tawas. Journal of Marine Research, 12(3), 527–536. https://doi.org/10.14710/jmr.v12i3.36450

Astuti, W., & Widihastuti. (2021). Kualitas Ketuaan Warna Hasil Pencelupan Pewarna Ekstrak Daun kakao Pada Kain Katun Primisima. Jurnal Pendidikan Teknik Busana, 1–8.

Chandanshive, V., Kadam, S., Rane, N., Jeon, B.-H., JeJadhav, J., & Govindwar, S. (2020). In situ textile wastewater treatment in high rate transpiration system furrows planted with aquatic macrophytes and floating phytobeds. Journal Chemosphere, 252.

Choudhury, A. K. R. (2018). Eco-friendly Dyes And Dyeing. Advanced Materials and Technologies Environmental Sciences, 2(1), 157–188.

Dutta, S., Adhikary, S., Bhattacharya, S., Roy, D., Chatterjee, S., Chakraborty, A., Banerjee, D., Ganguly, A., Nanda, S., & Rajak, P. (2024). Contamination of textile dyes in aquatic environment: Adverse impacts on aquatic ecosystem and human health, and its management using bioremediation. Journal of Environmental Management, 353.

Elgarahy, A. M., Elwakeel, K. Z., Mohammad, S. H., & Elshoubaky, G. A. (2021). A critical review of biosorption of dyes , heavy metals and metalloids from wastewater as an efficient and green process. Cleaner Engineering and Technology, 4(June), 100209. https://doi.org/10.1016/j.clet.2021.100209

Enrico. (2019). Dampak Limbah Cair Industri Tekstil Terhadap Lingkungan Dan Aplikasi Tehnik Eco Printing Sebagai Usaha Mengurangi Limbah. Jurnal Moda, 1(1), 5–13.

Farida, Atika, V., & Haerudin, A. (2016). Pengaruh Variasi Bahan Pra Mordan pada Pewarnaan Batik Menggunakan Akar Mengkudu (Morinda citrifolia). Jurnal Dinamika Kerajinan Dan Batik, 32(1), 1. https://doi.org/10.22322/dkb.v32i1.1164

Firdous, N., Shaikh, I. A., & Islam, S. (2024). Impacts on color properties of textile fabric following repetitive utilization of electro-coagulated dyeing wastewater. Journal Desalination and Water Treatment, 320.

Haerudin, A., Atika, V., Isnaini, Masiswo, Mandegani, G. B., Satria, Y., Lestari, D. W., Arta, T. K., Fitriani, A., & Hardjanto, P. (2020). Pengaruh Variasi Waktu, pH, Dan Suhu Ekstraksi Terhadap Kualitas Pewarnaan Ekstrak Kulit Buah Kakao (Theobroma cacao L .) Pada Batik Katun Dan Sutera. Jurnal Dinamika Kerajinan Dan Batik, 1(37), 25–40. https://doi.org/10.22322/dkb.v37i1.6019

Harmini, R. (2011). Pemanfaatan Bunga Rosela (Hibiscus sabdariffa) Sebagai Pewarna Alam Untuk Mencelup Serat Rayon. Industri Inovatif : Jurnal Teknik Industri, 1(1), 62–73.

Hasanudin, & Widjiati. (2002). Penilaian Proses Pencelupan Zat Warna Soga Alam Pada Batik Kapas. Departemen Perindutsrian dan Perdagangan Republik Indonesia. Balai Besar Penelitian dan Pengembangan Industri Kerajinan Batik.

Hidayat, N., Rusman, R., Suryanto, E., & Sudrajat, A. (2022). Pemanfaatan Bawang Dayak (Eleutherine palmifolia ( L ) Merr) Sebagai Sumber Antioksidan Alami pada Nugget Itik Afkir. Jurnal AgriTECH, 42(1), 30–38.

Junaidi, A. (2011). Pengembangan Produk Unggulan Jeruk Kalamansi Kota Bengkulu dengan Pendekatan Ovop. PT Swawra Unib.

Kartina, K., Nahariah, N., & Hikmah, H. (2022). Penambahan Jenis Dan Level Bahan Pengisi Yang Berbeda Terhadap Nilai Profil Warna L*, a*, b* Produk Chip Telur. JITP (Jurnal Ilmu Dan Teknologi Peternakan), 20(1), 6–10.

Kasmudjo, & Saktianggi, P. P. (2019). Pemanfaatan Daun Indigofera Sebagai Pewarna Alami Batik. Prosiding Seminar Nasional Masyarakat Peneliti Kayu Indonesia (MAPEKI) XIV, 542–548.

Kharisma, Y., & Sudiarso, A. (2020). Pengujian Ketahanan Luntur Warna Cokelat Pada Kain Batik Katun Dengan Pewarna Alami. Seminar Nasional Riset Dan Teknologi (SEMNAS RISTEK), 207–210.

Lalang, A. C., Christianto, H., Lestarani, D., Parera, L. A. M., & Murni, M. M. (2023). Etnokimia Pada Kain Tenun Songke Asal Desa Kakor Kecamatan Lembor Selatan Kabupaten Manggarai Barat, Nusa Tenggara Timur. Jurnal Βeta Kimia, 3(2), 15–28.

Maghfiroh, L., & Widowati. (2020). Kualitas Hasil Pencelupan Kain Mori Primissima Menggunakan Limbah Kulit Buah Naga Merah (Hylocereus polyrhizus). Fashion And Fashion Education Journal, 9(1), 70–77.

Manickam, P., & Vijay, D. (2021). 2 - Chemical hazards in textiles. In In The Textile Institute Book Series, Chemical Management in Textiles and Fashion (pp. 19–52). Woodhead Publishing.

Mayasari, D., Rusdiana, T., Kania, Y. R., & Abdasah, M. (2018). Stabilitas Ekstrak Umbi Bawang Tiwai (Eleutherine americana (L.) Merr.) Sebagai Pewarna Lipstik Terhadap Perubahan Suhu, Waktu, Kondisi Penyimpanan, pH dan Adanya Oksidator. Indonesian Journal of Pharmaceutical Science and Technology, 5(1), 8–13.

Mayasari, E., Rahayuni, T., & Erfiana, N. (2020). Studi Pembuatan Permen Jelly Dari Kombinasi Nanas (Ananas comosus L.) Dan Jeruk Sambal (Citrus microcarpa). Pro Food (Jurnal Ilmu Dan Teknologi Pangan), 6(2), 749–756. https://doi.org/10.29303/profood.v6i2.146

Musripah. (2019). Penggunaan Pewarna Alam Sebagai Inovasi Ramah Lingkungan Pada Karya Batik Ikat. Seminar Nasional Seni Dan Desain : Reinvensi Budaya Visual Nusantara, 277–282.

Nairfana, I., & Rizaldi, L. H. (2022). Sifat Fisikokimia Tepung Pisang Kepok (Musa paradisiaca L.) Yang Ditanam Di Lokasi Berbeda Di Kabuoaten Sumbawa. Pro Food (Jurnal Ilmu Dan Teknologi Pangan), 8(1), 44–52. https://doi.org/10.29303/profood.v8i1.233

Nofiyanti, N., Roviani, I. E., & Agustin, R. D. (2018). Pemnafaatan Limbah Kelapa Sawit Sebagai Pewarna Alami Kain Batik Dengan Fiksasi. The Indonesian Journal of Health Science, 45–54.

Olisah, C., Adams, J. B., & Rubidge, G. (2021). Ecotoxicology and Environmental Safety The state of persistent organic pollutants in South African estuaries : A review of environmental exposure and sources. Journal Ecotoxicology and Environmental Safety, 219, 112316. https://doi.org/10.1016/j.ecoenv.2021.112316

Priambudi, R. A., Tarigan, K. T., & Siswanti. (2020). Ekstrak Sabut Kelapa (Cocos nucifera) Sebagai Biomordan pada Bahan Tekstil Dengan Pewarna Alami Daun Jati (Tectona grandis L.f). Prosiding Seminar Nasional Teknik Kimia “Kejuangan†Pengembangan Teknologi Kimia Untuk Pengolahan Sumber Daya Alam Indonesia, 14–15.

Pujilestari, T., Pristiawati, E., Atika, V., & Haerudin, A. (2016). Pemanfaatan Zat Warna Alam Dari Limbah Perkebunan Kelapa Sawit Dan Kakao Sebagai Bahan Pewarna Kain Batik. Jurnal Dinamika Kerajinan Dan Batik, 33(1), 1–8.

Putra, G. H., Nurali, E. J. N., Koapaha, T., & Lalujan, L. E. (2012). Pembuatan Beras Analog Berbasis Tepung Pisang Goroho (Musa Acuminate) Dengan Bahan Pengikat Carboxymethyl Celluloe (CMC). Jurnal Ilmiah. Jurusan Teknologi Pertanian Fakultas Pertanian Universitas Sam Ratulangi.

Putri, A. M., Fatoni, R., & Haerudin, A. (2023). Pengaruh Variasi Konsentrasi Dan Jenis Fiksasi Pada Zat Warna Alam Daun Sirsak Terhadap Ketajaman Dan Ketahanan Luntur Warna Pada Kain Batik. Jurnal Riset Rumpun Ilmu Teknik (JURRITEK), 2(2), 148–157.

Ramadhan, F. H., Dewi, E. N., & Anggo, A. D. (2020). Pengaruh Perbedaan Konsentrasi Ekstrak Pewarna Alami Rumput Laut (Sargassum sp.) Terhadap Mutu Warna Kain Katun Batik. Jurnal Ilmu Dan Teknologi Perikanan, 2(2), 42–49.

Refordayanti, M. C., Putri, N. E. K., & Sastyarina, Y. (2021). Formulasi Sediaan Lipbalm Ekstrak Bawang Tiwai (Eleutherine Americana Merr) Sebagai Pelembab Bibir. Proceeding of Mulawarman Pharmaceuticals Conferences, April, 126–130.

Senorita, O., Nainggolan, R. J., & Lubis, L. M. (2018). Pengaruh Perbandingan Sari Bawang Dayak Dengan Sari Belimbing Wuluh Dan Lama Penyimpanan Terhadap Mutu Minuman Bawang Dayak. Jurnal Rekayasa Pangan Dan Pertanian, 6(4), 741–747.

Setiyani, & Yulistiana. (2023). Pemanfaatan Limbah Sabut Kelapa Sebagai Pewarna Alami Pada Kain Katun. E-Journal Edisi Yudisium, 12(1), 2–9.

Utami, T. D., Chalil, N. C., & Komalasari, M. (2023). Pengaruh Metode Mordan Pada Pencelupan Kain Nylon Menggunakan Zat Warna Alam Ekstrak Kulit Buah Rambutan (Nephelium Lappaceum L). Jurnal Texere, 21(1), 21–36.

Wicaksono, I. M., & Russanti, I. (2020). Pengaruh Jenis Fiksator Terhadap Hasil Jadi Pewarnaan Alami Dengan Air Rebusan Kenikir Pada Busana Anak. E-Journal Edisi Yudisium, 3(1), 34–38.

Zafar, S., Bukhari, D. A., & Rehman, A. (2022). Saudi Journal of Biological Sciences Azo dyes degradation by microorganisms – An efficient and sustainable approach. Saudi Journal of Biological Sciences, 29(12), 103437. https://doi.org/10.1016/j.sjbs.2022.103437

Downloads

Published

2024-10-31

How to Cite

Widyasari, I. A. M. T., Masriani, M., & Hairida, H. (2024). Utilization of Chili Citrus (Citrus microcarpa) as a Natural Fixator for Dyeing Cotton Fabrics with Dayak Onion Tuber Extract (Eluetherine palmifolia (L.) Merr). Hydrogen: Jurnal Kependidikan Kimia, 12(5), 1047–1057. https://doi.org/10.33394/hjkk.v12i5.12917

Issue

Vol. 12 No. 5 (2024): October 2024

Section

Articles

Citation Check

License

License and Publishing Agreement
In submitting the manuscript to the journal, the authors certify that:

  1. They are authorized by their co-authors to enter into these arrangements.
  2. The work described has not been formally published before, except in the form of an abstract or as part of a published lecture, review, thesis, or overlay journal.
  3. That it is not under consideration for publication elsewhere,
  4. That its publication has been approved by all the author(s) and by the responsible authorities – tacitly or explicitly – of the institutes where the work has been carried out.
  5. They secure the right to reproduce any material that has already been published or copyrighted elsewhere.
  6. They agree to the following license and publishing agreement.

Copyright
Authors who publish with Hydrogen: Jurnal Kependidikan Kimia agree to the following terms:

  1. Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License (CC BY-SA 4.0) that allows others to share the work with an acknowledgment of the work's authorship and initial publication in this journal. 
  2. Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgment of its initial publication in this journal.
  3. Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work.

Licensing for Data Publication

Hydrogen: Jurnal Kependidikan Kimia uses a variety of waivers and licenses, that are specifically designed for and appropriate for the treatment of data: Open Data Commons Attribution License, http://www.opendatacommons.org/licenses/by/1.0/ (default) Other data publishing licenses may be allowed as exceptions (subject to approval by the editor on a case-by-case basis) and should be justified with a written statement from the author, which will be published with the article.